Zero Motorcycles ZERO SRS 2025 8811934-AI (Preview)
EMEA (Europe, Middle East, Africa) Disclaimer
General Information
How To Use This Manual
Important Repair Information
Maintenance and Safety
Maintenance Intervals
Maintenance Intervals
Lockout Procedure
Lockout Procedure
Drive Belt Handling Guidelines
Drive Belt Handling Guidelines
Adjust Drive Belt
Drive Belt – Adjust
Brake Maintenance Procedures
Brake Bleeding Procedure (Front)
Brake Bleeding Procedure (Rear)
Brake Bedding
Key Programming
Key Programming
Motor Commissioning
Motor Commissioning
Motor Controller Firmware Update
Motor Controller Firmware Update
Power Pack
Power Pack
Power Pack
BMS (Battery Management System) [Before 2022MY]
Battery Management Unit (BMU) [22MY Onwards]
Power Pack Battery Signal Harness [Before 2022MY]
Power Pack Accessory Power Bus [Before 2022MY]
Power Pack Heat Sink Skins [Before 2022MY]
Service Cover [22MY Onwards]
Front Cover [22MY Onwards]
Rear Cover [22MY Onwards]
Mid Pack Protection Unit [22MY Onwards]
Top Cover [22MY Onwards]
Cooling Fan [22MY Onwards]
Assembly Cell Management Unit (CMU) [22MY Onwards]
Power Leads – Positive & Negative [22MY Onwards]
Contactor [22MY Onwards]
Controller BUS Set [22MY Onwards]
12 Volt Harness [22MY Onwards]
BCB Main BUS Set [22MY Onwards]
Charging System
Chargers
3KW Rapid Charger (Front) [Before 2022MY]
3KW Rapid Charger (Front and Rear) [Before 2022MY]
6KW Charger [22MY Onwards]
Charge Inlet Harness
DC/DC Converter
DC/DC Converter
Motor & Drive System
Motor
Motor
Motor Sprocket
Motor Stop Switch
Throttle (Without Heated Grips)
Throttle (With Heated Grips)
Motor Controller [Before 2022MY]
Motor Controller Carrier [Before 2022MY]
Motor Controller with Heatsink [22MY Onwards]
Drive Belt
Drive Belt – Replace
Rear Sprocket
Suspension
Front Suspension
Steering Stem
Fork Rebuild
Fork Alignment
Rear Suspension
Rear Shock
Swingarm
Doubler Plate Seals
Brakes
Brakes – Front
Brake Master Cylinder (Front)
Brake Lever (Front)
Brake Pads (Front)
Brake Caliper (Front)
Brake Rotor (Front)
Brakes – Rear
Brake Pads (Rear)
Brake Caliper (Rear)
Brake Rotor (Rear)
Rear Master Cylinder
Hydaulic Control Unit & Sensors
Hydraulic Control Unit (HCU)
Wheel Speed Sensor (Front)
Wheel Speed Sensor (Rear)
Wheels
Front Wheel
Front Wheel
Rear Wheel
Rear Wheel
Body
Trim
Rider’s Seat
Body
Headlight Upper Fairing
Headlight Inner Fairing
Hela Bracket
Tank Removal
Side Fairings (Outer)
Side Fairings (Inner)
Tank (Disassembly and Reassembly)
Grab Handles (Right and Left)
Tank Storage Liner
Tail
Tail Assembly
Electrical
High Voltage Fuses
High Voltage Fuses
12 Volt Battery
12 Volt Battery (Disconnect)
12 Volt Battery (Removal)
Lighting
Headlight
Headlight – Alignment
Tail Light
Turn Signal (Left Front)
Turn Signal (Right Front)
Turn Signal (Rear)
Instruments
Dash
Key Switch
Key Switch
Mode Switch
Mode Switch (Without Heated Grips)
Mode Switch (With Heated Grips)
Heated Grip
Heated Grips (Left)
Kickstand Switch
Kickstand Switch
Cellular Connectivity Module (CCM)
Cellular Connectivity Module (CCM)
Main Bike Board (MBB)
Main Bike Board (MBB)
There are no reviews yet.